Winnebago Chalet Owner's Manual

TO THE OWNERCongratulations! We welcome you to the exciting world of motor home travel and camping. You will find it convenient and enjoyable to have

INTRODUCTION0-1Congratulations on the purchase of your new Winnebago Chalet motor home, which has been carefully designed, engineered and quality buil

SECTION 9CARE & MAINTENANCE9-1ROOFThe roof is made of Thermo-Panel materials like the walls and floor. It will support the weight of an average ad

SECTION 9CARE & MAINTENANCE9-2to extreme sun, smog, soot or other environmen-tal pollutants.Stains and DiscolorationsRegular cleaning and waxing w

9-3SECTION 9CARE & MAINTENANCEINTERIORUPHOLSTERY, CARPETING AND DRAPERIESWe recommend a weekly routine of vacuum-ing all fabrics and carpet throug

SECTION 9CARE & MAINTENANCE9-4IMPORTANT: Make sure you have selected teh right cleaning agent from the list below before your begin the cleaning p

9-5SECTION 9CARE & MAINTENANCEIMPORTANT:The fabric manufacturer’s recommendeds made above are done in good faith and are based on a history of act

SECTION 9CARE & MAINTENANCE9-6RANGE AND REFRIGERATORFor care and appearance maintenance of the range and refrigerator, refer to the operation and

9-7SECTION 9CARE & MAINTENANCETIRESLow air pressure results in tire overloading and abnormal wear and also affects handling and fuel economy. Obta

SECTION 9CARE & MAINTENANCE9-8LIGHTSAll exterior lights should be checked for prop-er operation each time the vehicle is prepared for a trip. Any

SECTION 10STORING YOUR MOTOR HOME10-1PREPARING VEHICLE FOR STORAGEProperly preparing your vehicle for storage will lessen the possibility of damage to

SECTION 10STORING YOUR MOTOR HOME10-2right portion of the tank to prevent air lock-ing in the tank while draining.9. After water has stopped draining

INTRODUCTION0-2OPTIONS AND EQUIPMENTThis model is available in several sizes and floorplans, so accessories and components may differ slightly between

10-3SECTION 10STORING YOUR MOTOR HOMEtainer to determine the correct amount to use for your coach. See “Water System Winterization Valve” on page 7-4

SECTION 10STORING YOUR MOTOR HOME10-4seals tightly.10. Check around all appliances for obstructions and ensure that all vent openings are clear.11. St

INDEX110-Volt AC System... 6- 1110-Volt Circuit Breakers... 6- 3110-Volt Receptacles (Outl

INDEXFresh Water Tank Filling Procedure... 7- 1Fresh Water Toilet ... 8- 16Front Axle Tire Alignment ...

INDEXSSafe Use of the LP Gas System ... 5- 1Seat Belts ... 2- 7Seats ...

IMPORTANTSERIAL NUMBERSMotor Home (Coach): Year _________ Model ___________________ Serial _____________ Chassis: Make ___________________ Serial (

MAINTENANCE RECORDDateOdometerMileage Description of Service Cost

FUEL & OIL RECORDDateOdometerMileageFuelGal.OilQts. MPG Cost DateOdometerMileageFuelGals.OilQts. MPG Cost

FUEL & OIL RECORDDateOdometerMileageFuelGal.OilQts. MPG Cost DateOdometerMileageFuelGals.OilQts. MPG Cost

0-3INTRODUCTIONREPORTING SAFETY DEFECTSIf you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you sho

INTRODUCTION0-4VEHICLE CERTIFICATION LABELThis label contains vehicle identification and other important reference information. The vehi-cle certifica

0-5INTRODUCTIONEXTERIOR FEATURE IDENTIFICATION - Class C Motor HomesTypical model shown for illustration purposes only.Actual locations of features ma

SECTION 1SAFETY PRECAUTIONS1-1Read and understand all instructions and pre-cautions in this manual before operating your new motor home. About Safety

SECTION 1SAFETY PRECAUTIONS1-2 DRIVING• Do not attempt to adjust the driver’s seat while the vehicle is moving.• Do not adjust tilt steering in a mov

1-3SECTION 1SAFETY PRECAUTIONS• The following warning label is located in the cooking area to remind you to provide an ad-equate supply of fresh air f

SECTION 1SAFETY PRECAUTIONS1-4and roof vents, and leave the coach until the alarm stops sounding.If the alarm keeps sounding at regular inter-vals, a

NOTE: A ‘Note’ is not necessarily safety related but indicates a recommendation or special point of information that could assist in understanding the

1-5SECTION 1SAFETY PRECAUTIONS• Use caution when handling or working near electrical storage batteries. Always remove jewelry and wear protective clot

SECTION 1SAFETY PRECAUTIONS1-6recommended that the exhaust system and body be inspected by a qualified motor home service center.• Each time the vehic

1-7SECTION 1SAFETY PRECAUTIONSSide Escape WindowThe side mounted escape window is secured by two red safety latches and can be opened by first releasi

SECTION 1SAFETY PRECAUTIONS1-8We recommend that you become thoroughly familiar with the operating instructions displayed on the side of the fire extin

SECTION 2DRIVING YOUR MOTORHOME2-1(See also Safety Precautions, Section 1 of thismanual.)NOTE: See your Chevy or Ford chassis opera-tor's guide f

SECTION 2DRIVING YOUR MOTOR HOME2-2there is less chance of the doors flying open in event of an accident. It also prevents unin-tentional opening of d

2-3SECTION 2DRIVING YOUR MOTOR HOMEREPLACEMENT FUEL CAPSTo protect gasoline system from excessive pressure or vacuum, or from sudden pressure, re-plac

SECTION 2DRIVING YOUR MOTOR HOME2-4To lock the door from inside, rotate the lock levers as indicated. The deadbolt lock is for add-ed security and sho

2-5SECTION 2DRIVING YOUR MOTOR HOMEPower Steps - OptionalThe power Switch for the electric step is locat-ed to the left of the main entry door as you

SECTION 2DRIVING YOUR MOTOR HOME2-6SEATSThe driver and co-pilot seats may be indepen-dently adjusted to suit individual preference. To recline the sea

*LP Gas tank capacity shown is the usable “full” LP gas capacity, which is 80% of the tank manufac-turer’s listed water capacity (w.c. shown in parent

2-7SECTION 2DRIVING YOUR MOTOR HOMEARM REST ADJUSTMENTThe driver and co-pilot seat armrests may be adjusted to rest at two different positions as show

SECTION 2DRIVING YOUR MOTOR HOME2-8When the lap-shoulder belt is in use, the lap portion must ride across the strong hip area and the shoulder portion

2-9SECTION 2DRIVING YOUR MOTOR HOMETilt the surface of the mirror gently up or down, left or right, to obtain the best rear view.INSTRUMENT PANEL GAUG

SECTION 2DRIVING YOUR MOTOR HOME2-10INSTRUMENT PANEL(Ford Chassis)INSTRUMENT PANEL(Chevrolet Chassis*See chassis operating information.

2-11SECTION 2DRIVING YOUR MOTOR HOMESTEERING COLUMN CONTROLSSee your chassis operator guide for all con-trols located on the steering column or steeri

SECTION 2DRIVING YOUR MOTOR HOME2-12It is located on the lower dash panel as shown above.AUXILIARY BATTERY (Aux. Batt) SWITCHThis switch is intended t

2-13SECTION 2DRIVING YOUR MOTOR HOMETRAVEL STRAPSThe travel straps must be released before at-tempting to extend the room or damage to the coach will

SECTION 2DRIVING YOUR MOTOR HOME2-14• Set parking brake.• To extend the room, press and hold the “OUT” button.• When the room has reached its full ext

2-15SECTION 2DRIVING YOUR MOTOR HOME• The circuit breaker may be tripped. The cir-cuit breaker, labeled ‘Slideout Power’ is lo-cated on a panel on an

SECTION 2DRIVING YOUR MOTOR HOME2-16The crank sockets are located behind covers on the lower portion of the room on the outside of the coach. Your coa

2005 NEW VEHICLE LIMITED WARRANTY WINNEBAGO INDUSTRIES, INC. WARRANTY COVERAGE TO OWNER Winnebago Industries, Inc. of Forest City, Iowa warrants each

2-17SECTION 2DRIVING YOUR MOTOR HOMEIt may be necessary to move the handle slight-ly from side to side to fit it onto the shaft. The crank handle will

SECTION 2DRIVING YOUR MOTOR HOME2-18Semi-Manual Mode and or Crank Mode.Note: Manual Mode and corresponding Front and Rear Actuator locationsFront Actu

2-19SECTION 2DRIVING YOUR MOTOR HOME4. The slotted end of the tool must engage with the pin in the endshaft on the slideout gear assembly. See arrow i

3-1SECTION 3IN CASE OF DRIVING EMERGENCYHAZARD WARNING FLASHERThe hazard warning flasher provides addi-tional safety when the vehicle must be stopped

3-2SECTION 3IN CASE OF DRIVING EMERGENCYor rear tires, the following precautions should be headed:1. Park vehicle on level surface only.2. Turn off en

3-3SECTION 3IN CASE OF DRIVING EMERGENCYJUMP STARTINGCONNECTING JUMPER CABLES1. Make sure that the other vehicle has a 12-volt battery and negative gr

3-4SECTION 3IN CASE OF DRIVING EMERGENCYnegative (-) lead from the battery. Never discon-nect the battery while the engine is running or al-ternator d

4-1SECTION 4TRAVELING WITH YOUR MOTORHOME(See also SAFETY PRECAUTIONS, Section 1 of this manual.)LOADING THEVEHICLENOTE: Your motor home’s load capaci

SECTION 4TRAVELING WITH YOUR MOTOR HOME4-2Weigh Stations, etc. If you cannot locate a scale in your area, call your state DOT and ask for rec-ommendat

accompanies your motor home. Any damage which results to your vehicle as a result of your failure to perform such duties, is not covered. Damage to ap

4-3SECTION 4TRAVELING WITH YOUR MOTOR HOMEGAWR. For example, if the GAWR for the rear axle is 12,000 lbs., then the load on each rear dual set (left r

SECTION 4TRAVELING WITH YOUR MOTOR HOME4-4use of correct equipment. Select a drawbar that mates properly with the towing hitch receiver and provides p

4-5SECTION 4TRAVELING WITH YOUR MOTOR HOME− Exterior Door and Step - Make sure doors are closed, locked and step retracted.− Seats - Adjusted for comf

SECTION 4TRAVELING WITH YOUR MOTOR HOME4-6you and subject to change, sometimes with little or no warning. However, adequate warnings are normally broa

4-7SECTION 4TRAVELING WITH YOUR MOTOR HOMEheadlights periodically checked and adjusted.• Use care when passing other vehicles. Your motor home is a lo

SECTION 4TRAVELING WITH YOUR MOTOR HOME4-8so that the load weight is not resting on one tire, which could damage that tire.To provide extra firmness,

SECTION 5LP GAS SYSTEM5-1(See also Safety Precautions, Section 1 of this manual.)LP GAS SUPPLYThe LP gas system supplies fuel for the range, water hea

SECTION 5LP GAS SYSTEM5-2SELECTING LPFUEL TYPESWe recommend using straight propane in your LP gas tank. Propane gas is commonly available at all LP ga

5-3SECTION 5LP GAS SYSTEMdealership for filling. Do not attempt to remove the LP tank from the vehicle. The tank is equipped with a fill adapter with

SECTION 5LP GAS SYSTEM5-4Regulator freeze-ups are caused by the pres-ence of moisture in fuel. This moisture will pass through the cylinder valve and

TABLE OF CONTENTSINTRODUCTIONAbout This Manual ... 0- 1Chassis Operating Guide ... 0- 1

5-5SECTION 5LP GAS SYSTEMization rate of LP gas decreases in a direct rela-tionship to a decrease in temperature. Propane will convert to a usable gas

SECTION 6ELECTRICAL SYSTEMS6-1(See also Safety Precautions, Section 1 of this manual.)Your motor home is equipped with an electri-cal system consistin

SECTION 6ELECTRICAL SYSTEMS6-2The three-prong power cord is designed to ground the electrical system through the recepta-cle. It is also designed to c

6-3SECTION 6ELECTRICAL SYSTEMSConverter ChargerThe converter charges coach batteries while 110-volt external power is connected. The con-verter will a

SECTION 6ELECTRICAL SYSTEMS6-4GROUND FAULT CIRCUIT INTERRUPTERExterior, bath and galley outlets are connected to a GFCI (Ground Fault Circuit Interrup

6-5SECTION 6ELECTRICAL SYSTEMSStarting and Stopping the Generator The generator switch is located on the monitor panel. The generator starter circuit

SECTION 6ELECTRICAL SYSTEMS6-6Generator Hourmeter (If Equipped)This meter is located on the monitor panel. It registers the total number of hours that

6-7SECTION 6ELECTRICAL SYSTEMSuse. They will provide longer lasting power than standard automotive batteries, and will withstand the frequent drain-an

SECTION 6ELECTRICAL SYSTEMS6-8BATTERY STORAGE ANDMAINTENANCELead -acid type batteries are electro-chemical devices for storing and releasing electrica

TABLE OF CONTENTSSECTION 6: ELECTRICAL SYSTEM110-Volt AC System... 6- 1External Power Cord (Shoreline)...

6-9SECTION 6ELECTRICAL SYSTEMS• Clean and tighten battery terminals and have the specific gravity checked at least once a year.• Every two months, or

SECTION 7PLUMBING SYSTEMS7-1FRESH WATERSYSTEMThe fresh water system provides water to the galley sink, shower, bathroom lavatory, toilet and water hea

SECTION 7PLUMBING SYSTEMS7-27. Check to be sure pump stops soon after all faucets have been closed.8. Pump is now ready for automatic operation. Pump

7-3SECTION 7PLUMBING SYSTEMSdamage to any components, connections and seals in your fresh water system.A water pressure regulator may be ob-tained fro

SECTION 7PLUMBING SYSTEMS7-4can use the toilet, sinks and shower even in areas where utility hookups are not available.The main holding tank contains

7-5SECTION 7PLUMBING SYSTEMSgenerator must be operating, or the chassis engine must be running (such as when driving down the road). These three sourc

SECTION 7PLUMBING SYSTEMS7-6Leave by-pass valve handle inNORMAL FLOW position if drain-ing water and blowing out water lines. Place in BYPASS position

7-7SECTION 7PLUMBING SYSTEMSTANK CAPACITIESHT1 - Black Water Holding TankModels 322E (Toilet & Lavatory)...

SECTION 7PLUMBING SYSTEMS7-8324V (with rear bed)Water Lines:Water Tank:Water Heater:Water Heater By-Pass Valve:Winterization (Antifreeze)Valve:Exterio

TABLE OF CONTENTSLights ... 9- 8Automotive 12-Volt Fuses and Circuit Breakers ...

7-9SECTION 7PLUMBING SYSTEMS324F Water Lines:Water Tank:Water Heater:Water Heater By-Pass Valve:Winterization (Antifreeze)Valve:ExteriorShower:Two (2)

SECTION 7PLUMBING SYSTEMS7-10331C Water Lines:Water Tank:Water Heater:Water Heater By-Pass Valve:Winterization (Antifreeze)Valve:ExteriorShower:Two (2

SECTION 8APPLIANCES & INTERIOR FEATURES8-1(See also Safety Precautions, Section 1 of this manual.)NOTE: Because this model is available in sever-a

SECTION 8APPLIANCES & INTERIOR FEATURES8-2OPERATING INSTRUCTIONSNorcold Models with Electronic Auto Mode ControlStart-Up Instructions - Gas ModeTh

8-3SECTION 8APPLIANCES & INTERIOR FEATURESAUTO and MANUAL Modes - GasOperation OnlyIf the gas does not ignite within 30 seconds, which may occur o

SECTION 8APPLIANCES & INTERIOR FEATURES8-4To Open:1. Use a coin to turn the latch knobs to the ver-tical position as shown.2. Remove the door from

8-5SECTION 8APPLIANCES & INTERIOR FEATURESUse of Top Burners1. Light match.2. Apply lighted match to burner.3. Turn control knob back left (counte

SECTION 8APPLIANCES & INTERIOR FEATURES8-6Hood Fan And Light SwitchesTo turn on the range hood light, simply press the switch labeled “Hood Light”

8-7SECTION 8APPLIANCES & INTERIOR FEATURESNOTE: The holding tank heater pads are electri-cal resistance type heating elements. This type of heatin

SECTION 8APPLIANCES & INTERIOR FEATURES8-82. If “W.H. Pilot” light stays on longer than 15 seconds, place switch in “Off” position and wait 5 minu

8-9SECTION 8APPLIANCES & INTERIOR FEATURES5. Close the faucet and turn on the water supply before switching the water heater on.Manually operate t

SECTION 8APPLIANCES & INTERIOR FEATURES8-10To Shut Down:1. Slide SYSTEM switch to “OFF” position.2. Close LP tank valve.For Further InformationPle

8-11SECTION 8APPLIANCES & INTERIOR FEATURESDUCTED ROOF AIR CONDITIONING SYSTEMThe air conditioner is controlled by a thermo-stat located on a gall

SECTION 8APPLIANCES & INTERIOR FEATURES8-12All cooling functions controlling to setpoint have a short cycle protection time delay of 3 min-utes. T

8-13SECTION 8APPLIANCES & INTERIOR FEATURESTV SIGNAL AMPLIFIERNOTE: For coaches without the video control center option, be sure the TV antenna am

SECTION 8APPLIANCES & INTERIOR FEATURES8-14VIDEO SELECTOR SYSTEM - OptionalThe optional video selector system allows you to switch the antenna, ca

8-15SECTION 8APPLIANCES & INTERIOR FEATURESSLEEPING FACILITIESOVERHEAD FRONT BUNK (If equipped)The overhead front bunk is located above the driver

SECTION 8APPLIANCES & INTERIOR FEATURES8-16DINETTE/BED CONVERSIONTo Convert Dinette to Bed:1. Release the catch on the table leg brace and fold th

8-17SECTION 8APPLIANCES & INTERIOR FEATURES2. To flush the toilet, step on the small pedal to the right. (The black lever also moves the white lev

SECTION 8APPLIANCES & INTERIOR FEATURES8-18a few turns around the spools at the lower corners of the shades.To loosen the tension, unwrap the guid